Evaluation of shiitake production possibility on agricultural wastes and their effect on yield and biological efficiency

Asadi Doost Toli, Mitra; Behnamian, Mehdi; Dezhsetan, Sara

doi:10.22059/jci.2016.56586

Document Type : Research Paper

Authors

¹ Graduated M.Sc. Student, Department of Horticultural Sciences, Faculty of Agricultural Sciences, University of Mohaghegh Ardabili, Ardabil – Iran

² Assistant Professor, Department of Horticultural Sciences, Faculty of Agricultural Sciences, University of Mohaghegh Ardabili, Ardabil – Iran

³ Assistant Professor, Department of Agronomy and Plant Breeding, Faculty of Agricultural Sciences, University of Mohaghegh Ardabili, Ardabil – Iran

https://doi.org/10.22059/jci.2016.56586

Abstract

Edible shiitake mushroom is a relatively fragrant mushroom and grows on different types of dead hard woods. This mushroom ranks second in the world in total yearly mushroom production. On the hand, thousand tons of agricultural wastes are burned or discarded yearly. Hence, to evaluate the shiitake mushroom production possibility on agricultural wastes, an experiment designed based on completely randomized design with three replications. In this study, barley straw, millet straw and wheat straw used as main substrate with 10 and 20 percentage, respectively. The results showed that the highest biological efficiency were observed on barley straw (88.14 percent) and wheat straw with 20 percent sawdust (83.37 percent), respectively and the lowest biological efficiency were obtained on wheat straw (26.48 percent). In addition to, the highest yield was occurred on barley straw (25.28g/500g wet weight of substrate). However, the lowest yield observed on wheat straw (5.27g/500g wet weight of substrate), respectively. In general, the results showed that yield and biological efficiency of shiitake, on the barley and millet straw had increased as the level of sawdust boosted.

Keywords

20.1001.1.83372008.1395.18.2.19.0

References

1 . رازقی یدک ل، عزیزی م و فارسی م (1388) مطالعه تأثیر ترکیبهای مختلف سوبسترا بر فرآیند میوهدهی قارچ شیتاکه (اولین گزارش تولید در ایران). پژوهشهای زراعی ایران. 8(3): 501-507.

2 . محمدی گلتپه ا و پورجم ا (1383) اصول پرورش قارچهای خوراکی. چاپ ششم، دفتر نشر آثار علمی دانشگاه تربیت مدرس، تهران. 722 ص.

3 . Arora JK, Kakkar VK, Sukhvir K and Kaur S (1994) Bioconversion of agro residues for food and feed.Science andCultivation of Edible Fungi. 15: 3-4.

4 . Banik S and Nandi R (2004) Effect of supplementation of rice straw with biogas residual slurry manure on the yield, protein and mineral contents of oyster mushroom. Industrial Crops and Products. 20: 311-319.

5 . Caglarirmak N (2007) The nutrients of exotic mushrooms (Lentinula edodes and Pleurotus species) and an estimated approach to the volatile compounds. Food Chemistry. 105: 1188-1194.

6 . Chang ST and Miles PG (2004) Mushrooms cultivation, nutritional value, medicinal effect, and environmental impact. 2^nd Ed. CRC Press LLC, US, 477 p.

7 . Curvetto NR, Figlas D, Devalis R and Delmastro S (2002) Growth and productivity of different Pleurotus ostreatus strains on sunflower seed hulls supplemented with N-NH₄and/or Mn (II). Bioresource Technology. 84: 171-176.

8 . Gaitan-Hernandez R, Esquedda M, Gutierrez A and Beltran-Garcia M (2011) Quantitative changes in the biochimical compostitation of lignocellulosic residues during the vegetetive growth of Lentinula edodes. Brazilian Journal of Microbiology. 42: 30-40.

9. Gregori A, Vagelj M and Pohleven J (2007) Cultivation techniques and medicinal properties of Pleurotus spp. Food Technology and Biotechnology. 45: 238-249.

10 . Iqbal HMN, Asgher M and Bhatti HN (2011) Optimization of physical and nutritional factors for synthesis of lignin degrading enzymes by novel strain of Trametes versicolor. Bioresource. 6: 1273-1287.

11 . Jadhav DM and Gawai DU (2012) Effect of different nutrient sources on biomass production of phylloplane yeast Aureobasidium pullulans (De Bary). International Research Journal of Biological Sciences. 1: 85-87.

12 . Jonathan SG and Fasidi IO (2001) Effect of carbon, nitrogen and mineral sources on the growth of Psathyrella atroumbonata (Pegler), a Nigerian edible mushroom. Food Chemistry. 72: 479-483.

13 . Jones Jr and Benton J (2001) Laboratory guide of conducting soil tests plant and plant analysis. 3^th Ed. CRC Press LLC, US, 382 p.

14 . Kadriri M, Kehinde IA and Adegboye OTH (2007) Responses of Lentinula subnudus Berk to varying pH and photoperiods. Advances in Science and Technology. 2: 150-154.

15 . Korley-Kortei N and Wiafe-Kwagyan M (2014) Evaluating the effect of gamma radiation on eight different agro-lignocellulose waste materials for the production of oyster mushrooms (Pleurotus eous (Berk.) Sacc. strain P-31, Croatian. Journal of Food Technology. Biotechnology and Nutrition.9: 83-90.

16 . Mahdavi M and Bolandnazar S (2012) Application of organic nitrogen supplementations increases the yield of oyster mushroom (Pleurotus florida). Research in Plant Biology. 2: 10-15.

17 . Manzi P, Gambelli L, Marconi S, Vivanti V and Pizzoferrato L (1999) Nutrients in edible mushrooms: An inter-species comparative study. Food Chemistry. 65: 477-482.

18 . Martinez-carrera D, Aguilar A, Martinez W, Bonilla M, Morales P and Sobal M (2000) Commercial production and marketing of edible mushrooms cultivated on coffee pulp in Mexico. In: Sera T, Soccol C and Pandey A (Eds.), Coffee biotechnology and quality. Roussos, S. Pp. 471-488.

19 . Mata G, Gaitán-Hernández R, Pérez-Merlo R and Ortega C (2002) Improvement of Shiitake spawn for culturing on pasteurized wheat straw. Mushroom Biology and Mushroom Products. 968: 878-105.

20 . Mata G, Savoie JM, Delpech P and Olivier JM (1998) Reductions in the incidence of Trichoderma spp. using substrate supplementation with peat and an alternative spawn during cultivation of Lentinula edodes on pasteurised wheat straw. Agronomie. 18: 515-520.

21 . Nunes MD, DaLuz JMR, Paes SA, Ribeiro JJR, DaSilva MDCS and Kasuya MCM (2012) Nitrogen supplementation on the productivity and the chemical composition of oyster mushroom. Journal of Food Research. 1: 113-119.

22 . Okhuoya JA, Akpaja, EO, Osemwegle OO, Oghenekaro AO and Ihayere C (2010) Nigerian mushrooms: underutilized non-wood forest resources. Journal of Application Sciences in Environmental Management. 14: 43-54.

23 . Patil S (2012) Cultivation of Pleurotus sajor-caju on different agro wastes. Science Research Reporter. 2: 225-228.

24 . Peksen A and Ozcelik E (2007) Hazelnut husk as a substrate for the cultivation of shiitake mushroom (Lentinula edodes). Bioresource Technology. 98: 2652-2658.

25 . Philippoussis A, Diamantopoulou P and Israilides C (2007) Productivity of agricultural residues used for the cultivation of the medicinal fungus Lentinula edodes. International Biodeterioration and Biodegradation. 59: 216-219.

26 . Rossi IH, Monterio AC, Machado JO, Andrioli JL and Barbosa JC (2003) Shiitake (Lentinula edodes) production on a sterilized bagasse substrate enriched with rice bran and sugarcane molasses. Brazilian Journal of Microbilogy. 34: 66-71.

27 . Royse DJ (1985) Effect of spawn run time and substrate nutrition on yield and size of the shiitake mushroom. Mycologia. 77: 756-762.

28 . Royse DJ and Sachez JE (2007) Ground wheat straw as a substitute for oak wood chips used in shiitake (Lentinula edodes) substrate formulae. Bioresource Technology. 98: 2137-2141.

29 . Sánchez C (2010) Cultivation of Pleurotus ostreatus and other edible mushrooms. Applied Microbiology and Biotechnology. 85: 1321-1337.

30 . Seungwoo K (2005) Mushroom growers' handbook 2. 1^th Ed. MushWorld, Korea, 292 p.

31 . Shaw K (1959) Determination of organic carbon in soil and plant material. Journal of Soil Science. 10: 316-326.

32 . Shen Q, Lio P, Wang X and Royze DJ (2008) Effects of substrate moisture content, sand filter porosity on shiitake (Lentinula edodes) yield.Bioresource Technology. 99: 8212-8216.

33 . Song CH and Chow KY (1987) A synthetic medium from the production of submerged cultures of Lentinus edodes. Mycologia. 79: 866-876.

34. Stajic M, Persky L, Hadar Y, Friesem D, Dultic-Lausevic S, Wasser SP and Nevo E (2006) Effect of copper and manganese on activies of laccase and peroxidase in three Pleurotus species grown on agricultural wastes. Applied Biochemistry andBiotechnology. 128: 87-96.

35 . Sudha H and Padma N (2013) Optimization of lignin peroxidase, manganese peroxidase, and lac production from Ganoderma lucidum under solid state fermentation of pineapple leaf. Bioresources. 8: 250-271.

36 . Van Soest PJ (1994) Nutritional ecology of the ruminant. 2^th Ed. Cornell University Press, Ithac. 488 p.

37 . Van Soest PJ, Robertson JB and Lewis BA (1991) Methods for dietary fiber neutral detergent fiber and non-starch polysaccharide in relation to animal nutrition. Journal of Dairy Sciences. 74: 3583-3597.

38 . Worrall JJ and Yang S (1992) Shiitake and oyster mushroom production on apple pomace and sawdust. Applied Biochemistry andBiotechnology.27: 1131-1133.

39 . Yiliz A (1999) The effects of some plant materials on the growth and productivity of Pleurotus florida Fovose. Turkish Journal of Biology. 23: 67-72.

Journal of Crops Improvement

Evaluation of shiitake production possibility on agricultural wastes and their effect on yield and biological efficiency

References

References

Volume 18, Issue 2
July 2016
Pages 521-530

Evaluation of shiitake production possibility on agricultural wastes and their effect on yield and biological efficiency

References

References

Volume 18, Issue 2July 2016Pages 521-530

Volume 18, Issue 2
July 2016
Pages 521-530